Graco 495st B Pro (100-140 VAC) Airless Paint Sprayers

Your One-Stop Source for OEM Graco 495st B Pro (100-140 VAC) Airless Paint Sprayers Parts & Kits

Graco 495st B Pro is the go-to 120-volt rig for renovation pros who need a reliable 0.60 GPM / 3,000 psi workhorse that slides under van shelves yet keeps up with half-inch hose runs. From fine-finish lacquer to block-filler primer, it sprays clean all day—until wear parts inevitably tap out. Swap in generic seals and you risk phantom pressure spikes, drippy tips, and lost bids. Stick with OEM parts from SprayersAndParts and SmartControl™ stays rock-steady, overspray shrinks, and profit climbs.

Six Reasons Pros Stick with Factory-Engineered Components

• Precision Machining ±0.002 in — Chromex™ rods and Blue V-Max packings seat perfectly, eliminating “fingering” on finish coats.
• 3000 psi Safety Margin — Hoses, O-rings, and seats are rated beyond the sprayer’s max; off-brand kits tap out at 2 k.
• QuikPak™ Pump Lower — Pull two pins, slide, prime—back to spraying in five minutes, zero loose springs to chase.
• Gear-Train Warranty — Valid only with OEM gears and seals; keep that paperwork (and payout) intact. 
• SmartControl 3.0 — Factory sensor tolerances keep pressure dead-steady, cutting tip wear 30 %.
• BlueLink™ Telemetry — Track gallons, hours, and locations from your phone; schedule seal kits before failures snowball.

Need-to-Know Technical Specs

Drop-In Fit for Multiple Rigs

Stock one parts kit and keep half your fleet humming—the 495st B Pro pump, filters, and control boards also bolt into:

• Ultra Max II 495 PC Pro Stand & Lo-Boy (identical lower). 
• Ultra Max II 595 Stand (shared packings & rod).
• Graco 650 Pro with 17H200 manifold retrofit.
• LineLazer 3400 stripe pump (uses 17C718 lower).
• DutyMax GH 130 when confined power makes electric essential.

How OEM Upgrades Pay for Themselves—By the Numbers

Fuel-Free Efficiency — Tight packings lower amp draw 8 %, letting a 2 kW generator run in eco-mode.

Tip Longevity — Clean 60-mesh Easy-Out™ filters prevent grit that rounds graco spray tips and guards; test panels show 30 % longer edge life.

Less Rework — Steady pressure lets you spray trim at 2,200 psi, erasing cat-tails on oak cabinets.

Five-Minute Pump Swaps — Spare QuikPak™ lowers cost less than a single hour of idle payroll; pull, pin, prime, bill.

Warranty Shield — Gear-train claims average $700; OEM parts keep the lifetime coverage alive.

Resale Premium — Used sprayers with full OEM service logs fetch up to 20 % more at auction.

Bundle & Save—Popular Add-Ons That Ship Today

1. graco truecoat 360 parts list—handhelds for punch-lists and colour tests.
2. graco sprayer accessories—BlueMax™ hoses, Inline filters, Pump Armor.
3. graco paint sprayer gun parts in houston texas—same-day pickup for Gulf Coast shutdowns.
4. graco accessories—hoppers, guard extensions, texture adapters.
5. graco spray tips and guards—RAC X LP tips from .013 to .025.
6. Buy Graco X7 and LTS 17 Diagram and Parts—train new hires on familiar controls.
7. graco truecoat 360 vsp parts—variable-speed repairs in one grab-and-go kit.
8. graco airless paint sprayers—scale your fleet without a learning curve.

Field-Tried Tips for Keeping Your 495st B Pro Spraying Smooth

• Add a dime of TSL throat-seal lubricant every morning.
• Flush warm (45 °C) water—melts latex four times faster than cold; save solvent for oil jobs.
• Rotate tips: .021 for primer, .015 for finish—doubling tip life.
• Record gallons in BlueLink™; rebuild packings at 500 k cycles.
• Colour-code bins so sprayer accessories never mingle with gun kits—one rogue O-ring can idle a $7k rig.
• Laminate the X7/LTS 17 diagram for at-a-glance torque checks in the trailer.

Ready to Spray Faster & Bill More?

Click Add to Cart for genuine Graco 495st B Pro parts. Backed by Graco’s factory warranty.